,
(Prepared According to 29 CFR 1910.1200) Date Prepared: February 4, 2001 Revised: September 11, 2005
Prepared by: Robert V. Johnson Date Printed: September 11, 2005
|
SECTION 1 - PRODUCT AND
COMPANY IDENTIFICATION: |
|
Company Name: KLEERWITE
CHEMICAL 24 Hour Emergency Phone:
1-800-535-5053 (InfoTrac) |
|
P. O. BOX 10428, BURKE, VA 22009-0428, 703-451-3964; FAX: 703-451-7362 |
|
Trade Name: DWX-44 Product Type: DETERGENT |
|
SECTION 2 - INGREDIENT INFORMATION:
Not considered hazardous under 29 CFR 1910.1200 This product is
100% Biodegradable. Contains no
petroleum solvents or V.O.C.’s. Contains no products on the Federal H.A.P.
list. |
|
CHEMICAL NAME/COMMON NAME CAS NO. PERCENTAGE |
|
WATER 7732-18-5 75 – 85% |
|
SURFACTANT BLEND – NON HAZARDOUS MIXTURE 15 – 25% |
|
SARA HAZARD TITLE III, SECTION 313-Contains no ingredient
listed as a Hazardous Substance (40
CFR-355) |
|
SECTION 3 - HEALTH HAZARD DATA: |
|
Primary Routes of Exposure Eye [X] [X] Skin [X] Oral [ ] Inhalation [ ] Other |
|
Overexposure Effects: Irritating to mucous membranes, eyes and skin. May cause slight eye irritation. |
|
Threshold Limit Value: Not Established. |
|
H.M.I.S Values: Health (Blue) -1; Flammability (Red) - 0; Reactivity (Yellow) -0; Personal Protection – A |
|
Carcinogen or Suspect Carcinogen Ingredients [ ] NTP [ ] IARC [ ] OSHA [ X ] None |
|
SECTION 4 - FIRST AID
MEASURES: |
|
Eyes: Remove contact lenses. Flush eyes with water for 15 minutes, get prompt medical attention. |
|
Skin: Flush skin with water. Remove contaminated clothing. |
|
Ingestion: Rinse mouth and give several glasses of water. Do not induce vomiting. NEVER give anything by mouth to an unconscious person. Get medical attention. |
|
Inhalation: Seek well-ventilated area. If irritation persists seek medical attention. |
|
SECTION 5 - FIREFIGHTING
MEASURES: |
|
Flash Point (T.C.C.) Not applicable Flammable Limits Upper: Not Flammable; Lower: Not Flammable |
|
Extinguishing Media: Foam, CO2, Water fog, BC/ABC Extinguisher may be used in area where material is stored. |
|
Special Firefighting Procedures: None known |
|
Unusual Fire and Explosion Hazards: None known |
|
SECTION 6 - ACCIDENTAL RELEASE MEASURES: |
|
If Released or Spilled: Stop leaks. Soak up spill with rags or towels. |
|
Waste Disposal Methods: Dispose of spill byproducts according to State and Federal Regulations. Not a hazardous waste under CERCLA or RCRA, 40CFR; 261 |
|
SECTION 7 - STORAGE AND HANDLING INFORMATION: |
|
Store in a cool, dry area. Do not allow product to freeze. Do not get in the eyes, on skin or on clothing. Do not take internally. |
|
SECTION 8 - SPECIAL
PROTECTION INFORMATION |
|
Respiratory Protection: Not needed under normal condition of use. Ventilation Requirements: [X] Local Exhaust [ ] Mechanical |
|
Protective Gloves: Recommended for prolonged contact Eye Protection: Not necessary Other protective Clothing: None needed |
|
SECTION 9 - PHYSICAL AND CHEMICAL
PROPERTIES: |
|
Boiling point (0F.) Above 200°F Density (lb/gl) 8.34 Specific Gravity (H2O = 1) 1.0 pH (1%) = 8.5 |
|
Vapor Pressure (mm Hg) <0.01 mm Hg Vapor Density (Air = 1) >1.0 Evaporation Rate (vs. Ether): [ ] Faster [X ] Slower |
|
Solubility in water: [X] Complete [ ] Insoluble [ ] Emulsifiable (or Dispersible) [ ] Slight (or Partial) |
|
Appearance and Odor: Odorless, clear liquid. |
|
SECTION 10 - STABILITY AND REACTIVITY: |
|
Stability: Stable Incompatibility: Oxidizers Hazardous Decomposition Products: None known. |
|
SECTION 11 - TRANSPORTATION INFORMATION: |
|
Proper Shipping Name: COMPOUNDS, CLEANING LIQUID |
|
D.O.T. Hazard Class: NOT REGULATED UN Number: N/A Packaging Group: N/A Label Required: NONE |